North Bay Truck Center: June 2023

6/30/23

Drivetrains 101 | Consumer Reports

A car’s drivetrain is how you get power from the engine to the wheels. Consumer Reports’ expert explains the difference between front-wheel, rear-wheel drive, all-wheel, and four-wheel drive.

6/27/23

Good Headlights Mean Fewer Crashes - IIHS News

Good IIHS headlight ratings linked to lower crash rates

The headlight ratings program developed by the Insurance Institute for Highway Safety is reducing dangerous nighttime crashes in the real world, a recent study shows.

Nighttime crash rates per mile are nearly 20 percent lower for vehicles with headlights that earn a good rating in the IIHS evaluation, compared with those with poor-rated headlights, the study found. For vehicles with acceptable or marginal headlights, crash rates are 15 percent and 10 percent lower than for those with poor ratings.

6/24/23

Checking Your Tires for Towing

It's a good idea to check your tires before towing

6/21/23

SAFE STEPS Road Safety: Speed Limits

We all have a role in road safety! So follow these SAFE STEPS to play your part and help save lives. - Obey speed limits - - Slow down at high risk areas - - Keep a safe distance -

6/18/23

Inspecting and Maintaining Tires Will Minimize Roadside Service Calls

It is well documented that the No. 1 cause of roadside service calls is tires. No wonder, there are 18 tires on a typical line-haul service vehicle, more tires than any other vehicle component. You can have the best vehicle maintenance program on the planet, but once that truck leaves the terminal, a number of tire issues can occur that can lead to a roadside service call.

Tread area punctures are the top cause of air loss. A tire failure depends on the size of the puncturing object, in combination with the specific penetration location. If that nail penetrates through one of the tread grooves, chances are higher the nail will break through the tire casing, causing air loss. Tires do not normally have a sudden air loss when a vehicle picks up a puncturing object; they lose air slowly. It may take a few days to lose enough air pressure where the tire sidewalls begin excessive flexing, which generates additional heat build-up.

The tire footprint becomes longer as the tire pressure is reduced, meaning more rubber on the road—which also leads to increased heat. Heat is a tire’s worst nightmare. When a tire continues to generate excessive heat, the rubber actually begins to chemically break down, which will lead to a tire failure. The fact that someone just checked all 18 tires at the morning vehicle walk-around has no bearing on picking a up a nail five minutes down the road.

Sidewall damage/snags are another cause of tire failure. Right side or curb side trailer tires are especially prone to sidewall issues. Vehicles that turn frequently in city driving have the highest incidence of tire sidewall damage. Driver education can play a major role in reducing trailer tire sidewall damage. Drivers who have been on the road for many years will have fewer trailer tire sidewall damage issues than a new driver.

When a vehicle is pulled over for a roadside inspection, tires are high up on the inspector’s checklist. Inspectors are looking for tires with tread depth below the minimum 4/32-in. for steers and 2/32-in. for drives, trailers and dollies. They also are looking for exposed belts and/or fabric along with flat tires. By definition, a tire is flat when the measured air pressure is 50% or less of the maximum tire pressure molded onto the tire sidewall.

If any of these tire conditions are present, the vehicle is flagged as being “out-of-service.” A roadside service call is the only solution for getting the truck up and running again.

There is no excuse for a fleet to have an inspector flag its vehicle as being out-of-service because of a tire-related issue. These types of tire conditions should have been caught during the daily vehicle walk-around. Drivers must be trained to visually inspect tires, take tread depths and even measure tire pressure. It sounds like it is routine, but it’s not. Working with your tire professional on a tires 101 training class will go a long way to reduce roadside service calls.

Visual tire inspections should include running a hand over the tread and sidewall to look for signs of irregular wear and punctures. If a tire is getting close to the legal tread depth, a tread depth gauge measurement is strongly suggested. Make sure to check that the tread depth gauge measures 0 on a flat. Don’t take a measurement at a treadwear indicator location or on top of one of those stone ejectors located at the bottom of many grooves. If you do, you could be off 2/32-in. or 3/32-in.

Measuring tire pressure using a calibrated pressure gauge is very critical. Air carries the load, and tires with low air pressure will lead to excessive heat and premature tire removals. Tire gauges are simple devices, but will quickly lose accuracy. Even a new stick gauge is only accurate to +/-3 PSI brand new, out of the box.

A serious tire program, which includes comprehensive driver training regarding tires, will go a long way in reducing-tire related roadside service calls.

Learn more at: http://www.fleetequipmentmag.com/reducing-tire-related-roadside-service-calls/

Find Truck Tires here.

6/12/23

Tour of the Trailer Parts inventory at North Bay Truck Center

North Bay Truck Center in Fairfield CA has a huge selection of heavy duty trailer parts including bearings, axle assemblies, hubs, and much more. Heavy duty truck and trailer repair is our specialty, and we also work on light duty trucks. We have an extremely well stocked parts department to take care of almost any need in a hurry. See more about North Bay at http://www.northbaytruckcenter.com

6/11/23

Drivetrains 101 | Consumer Reports

A car’s drivetrain is how you get power from the engine to the wheels. Consumer Reports’ expert explains the difference between front-wheel, rear-wheel drive, all-wheel, and four-wheel drive.

6/09/23

A&T Road Service NRC Quickswap & Tag Axle Can Tow HD trucks, buses and mobile homes

Call 800-434-1205

A&T Road Service added Truck 32 in 2014. It was a brand new 2014 Kenworth with a 500 hp Cummins and an 18-speed gearbox is outfitted with an NRC Quickswap detachable tow unit with a tag axle for extra capacity. This allows the truck to be a wrecker and also a transfer vehicle, so with the unit disconnected, it will tow mobile home units, trailers of all kinds and with the wrecker unit attached is capable of lifting up to 20,000 lb steer axles for heavy-duty truck towing. This unit can easily to HD trucks, buses, mobile homes.

It is outfitted with tools and parts to make minor mechanical repairs, air-line repair, fuel line repairs, add fuel, and can take care of any DEF needs. It is also equipped with extra high-intensity lights for more effective and efficient night work since A&T Road Service is available 24 hours a day.

Visit A&T Road Service at https://www.truckmobilerepair.com/

And North Bay Truck Center is centrally located in Fairfield CA to service all of Solano County along with much of the San Francisco/Oakland bay area and Sacramento. A&T Road Service is available by calling 800-434-1205, You can also visit the NBTC website at http://www.NorthBayTruckCenter.com